Marc's 1990 4.2L V8 Twin Turbo Coupe Quattro

Document and share your build!
quattrofrog

Post by quattrofrog »

Hey Marc... Are your turbochargers are supported from beneath by braces or just by the manifolds? I can't remember how you have it configured.
User avatar
Marc
Posts: 1586
Joined: Wed Feb 27, 2013 1:33 pm

Post by Marc »

Wizard-of-OD wrote:Marc you going to eliminate that idler pulley up front?


I haven't had any more problems with blowing up serp belts but I would like to get rid of the top roller. In theory all I should need is a straight shot between the crank pulley and the alternator with some sort of spring loaded tension roller pushing in the back side of the belt to keep it tensioned, essentially eliminating the pulley that used to be used for the viscous fan.
Marc Swanson
Proprietor, EFI Motorsport
User avatar
Marc
Posts: 1586
Joined: Wed Feb 27, 2013 1:33 pm

Post by Marc »

quattrofrog wrote:Hey Marc... Are your turbochargers are supported from beneath by braces or just by the manifolds? I can't remember how you have it configured.


just the manifolds. They are so short I really dont think bracing is necessary.
Marc Swanson
Proprietor, EFI Motorsport
RSCoupe

Post by RSCoupe »

a4kquattro wrote:yeah, when you track high HP turbos the heat and vibration plays hell on the fasteners. I used high temp loctite on the fasteners, in this case it was the studs securing the turbo to the manifold that started to back out (the nuts were still securely in place). next step is some nice mechanical locking tabs I seem to recall seeing in the 034 motorsport catalog ;)


Definitely. I had to use the locking tabs on mine, as it was the only way to keep the hardware tight. It would only take a couple sessions and it would be loose, and the gasket would be burned out.
http://www.034motorsport.com/product_in ... ts_id=1329
User avatar
Marc
Posts: 1586
Joined: Wed Feb 27, 2013 1:33 pm

Post by Marc »

Image

Image

engine is out, car is pushed outside so I can keep the doors closed and swap some of the custom parts off the 3.6 onto the 4.2. Parts I will be swapping include:


oil pan (clearanced for the subframe)
crank pulley (60-2)
t-belt covers (powdercoated)
valve covers (powdercoated)
exhaust manifolds/turbos (duh)


I'll need to drill some holes in the 4.2 block while I've got the pan off for the turbo drains as well as some new provisions for catch can drain back...
Marc Swanson
Proprietor, EFI Motorsport
AudiSport4000
Posts: 795
Joined: Wed Feb 27, 2013 12:53 pm
Location: Fort Wayne, IN

Post by AudiSport4000 »

:woowoo: :woowoo: :woowoo: :woowoo:
1986 4kq Commemorative Design
2012 Jetta TDI

Follow me on YouTube at Mike's Virtual Garage!
https://www.youtube.com/channel/UCaMvwkjuW7Ziy5pmfVh_PJQ/
Derracuda
Posts: 264
Joined: Wed Feb 27, 2013 5:22 pm

Post by Derracuda »

8)
Jonathan

Post by Jonathan »

Marc,

You get the MG prize for "together again, apart again." :)
RSCoupe

Post by RSCoupe »

:woowoo:
Zzak

Post by Zzak »

Ok you motivated me to pull the 2 VEMS harness wires thru my firewall so there. Now I'm getting some whiskey to warm me up.
User avatar
Marc
Posts: 1586
Joined: Wed Feb 27, 2013 1:33 pm

Post by Marc »

Zzak wrote:Ok you motivated me to pull the 2 VEMS harness wires thru my firewall so there. Now I'm getting some whiskey to warm me up.


ooh. thats a good idea. off to the booze cabinet I go!
Marc Swanson
Proprietor, EFI Motorsport
3bAudios

Post by 3bAudios »

:woowoo: nice going Marc i take it it warmed up enough to get a little work done, nice
HT Motorsport
Posts: 350
Joined: Wed Feb 27, 2013 11:56 am

Post by HT Motorsport »

Very cool, well cold really ;)

Nice work Mark, cant wait to find out more. :woowoo:
onfir3

Post by onfir3 »

Holy hell, that motor is dead sexy. I've got to say, that's pretty sharp.
So, I'm really tired right now, but I'll read through this at a later time.
What's the status? Getting it ready to go in and all? Does it run?
feel free to :bashtard: me later.
Derracuda
Posts: 264
Joined: Wed Feb 27, 2013 5:22 pm

Post by Derracuda »

RS6 on the cheap! :D
WAUG0806

Post by WAUG0806 »

derracuda wrote:RS6 on the cheap! :D


RS6 on a diet...
User avatar
Marc
Posts: 1586
Joined: Wed Feb 27, 2013 1:33 pm

Post by Marc »

WAUG0806 wrote:
derracuda wrote:RS6 on the cheap! :D


RS6 on a diet...


Coupe is still a pig, 400whp takes care of that nicely.

I'm hoping for 500whp on pump with the 4.2, possibly 600 on E85 :-D
Marc Swanson
Proprietor, EFI Motorsport
User avatar
Marc
Posts: 1586
Joined: Wed Feb 27, 2013 1:33 pm

Post by Marc »

put the engine up on a stand tonight:

Image

pulled the lower and upper oil pans, since those will be swapped onto the 4.2

Image

Image

next up is to lift the 4.2 off the ground and pull the upper and lower pans, drill the oil return lines into the engine block, as well as a yet to be determined catch can drain back hole.

man alive there are a lot of oil pan bolts on these things.
Marc Swanson
Proprietor, EFI Motorsport
Toxcheap

Post by Toxcheap »

good work and all that stuff
HT Motorsport
Posts: 350
Joined: Wed Feb 27, 2013 11:56 am

Post by HT Motorsport »

Toxcheap wrote:good work and all that stuff


Aye, garage is looking sorted too ;)
User avatar
Marc
Posts: 1586
Joined: Wed Feb 27, 2013 1:33 pm

Post by Marc »

timmmy wrote:
Toxcheap wrote:good work and all that stuff


Aye, garage is looking sorted too ;)


says the man with a monster sized garage. Asshat :)
Marc Swanson
Proprietor, EFI Motorsport
Toxcheap

Post by Toxcheap »

timmmy wrote:
Toxcheap wrote:good work and all that stuff


Aye, garage is looking sorted too ;)


HAHAHA!!
At least this time I don't have to see it in person, although right now I can't talk my garage is a war zone with absolutely no free space to work. :(
RSCoupe

Post by RSCoupe »

a4kquattro wrote:
timmmy wrote:
Toxcheap wrote:good work and all that stuff


Aye, garage is looking sorted too ;)


says the man with a monster sized garage. Asshat :)


:lol:
WAUG0806

Post by WAUG0806 »

Good to see you back at it!

I spent 16+ hours straightening up my huge garage mess this weekend... parting cars a very messy proposition and another incoming orphan soon... lots of energy and did not touch a car.
User avatar
Marc
Posts: 1586
Joined: Wed Feb 27, 2013 1:33 pm

Post by Marc »

life has been busy lately.

Closing on my house the 16th of this month (fingers crossed). I did manage to sneak out to the garage tonight to tighten the oil pan bolts for the swapped mid and lower oil pans (all eleventy billion of them).

Next up is R&Ring the waterpump and idler rollers and installing some new seals, swapping over the powdercoated timing belt rear cover plates for the heads, then install the t-belt..
Marc Swanson
Proprietor, EFI Motorsport
Post Reply